conductive polymer aluminum solid electrolytic capacitors cv series chip type, high voltage / long life specifications temperature characteristics (max.impedance ratio) category temperature range rated voltage range rated capacitance range capacitance tolerance tangent of loss angle (tan ) esr (1) leakage current ( 2) performance characteristics item 55 to +105? 16 to 125v 5.6 to 680 f 20% at 120hz, 20? less than or equal to the specified value at 120hz, 20? less than or equal to the specified value at 100khz, 20? less than or equal to the specified value . after 2 minutes' application of rated voltage at 20? z+105? / z+20? 1.25 (100khz) z 55? / z+20? 1.25 endurance damp heat (steady state) resistance to soldering heat marking the specifications listed at right shall be met when the capacitors are restored to 20? after the rated voltage is applied for 3000 hours at 105?. the specifications listed at right shall be met when the capacitors are restored to 20? after the rated voltage is applied for 1000 hours at 60?, 90% rh. after soldering the capacitor under the soldering conditions prescribed here, the capacitor shall meet the specifications listed at right, provided that it's temperature profile is measured at the capacitor top and the terminal. pre-heating shall be done at 150 to 200? and for 60 to 180 sec. the duration for over +230? temperature at capacitor surface shall not exceed 60 seconds. in the case of peak temp, less than 250?, reflow soldering shall be two times maximum. in the case of peak temp, less than 260?, reflow soldering shall be once. measurement for solder temperature profile shall be made at the capacitor top and the terminal. navy blue print on the case top capacitance change tan leakage current ( 2) esr (1) within 20% of the initial capacitance value ( 3) 150% or less than the initial specified value 150% or less than the initial specified value less than or equal to the initial specified value capacitance change tan leakage current ( 2) esr (1) within 20% of the initial capacitance value ( 3) 150% or less than the initial specified value 150% or less than the initial specified value less than or equal to the initial specified value capacitance change tan leakage current ( 2) esr (1) within 10% of the initial capacitance value ( 3) 130% or less than the initial specified value 130% or less than the initial specified value less than or equal to the initial specified value high voltage (to 125v), low esr, high ripple current. load life of 3000 hours at 105?. smd type : lead free reflow soldering condition at 260? peak correspondence. compliant to the rohs directive (2002/95/ec). 1 esr should be measured at both of the terminal ends closest where the terminals protrude through the plastic platform. 2 conditioning : if any doubt arises, measure the leakage current after the voltage treatment of applying dc rated voltage continuously to the capacitor for 120 minutes at 105?. 3 initial value : the value before test of examination of resistance to soldering. p 1 c 2 v 3 1 4 v 5 8 6 2 7 0 8 m 9 c 10 l 11 1 12 g 13 s 14 configuration taping code size code capacitance toleranc ( 20%) rated capacitance ( 82f ) rated voltage ( 35v ) series name type cv 82 v 012 h 0.3 max. d + 0.5 max. b 0.2 a 0.2 c 0.2 0.5 max. e l series voltage (v:35v) plastic platform lot no. capacitance negative positive +0.1 -0.4 dimensions type numbering system (example : 35v 82f) dimension table in next page. cv high temperature d l a b c e h 6.3 5.9 7.3 6.6 6.6 2.1 0.5 to 0.8 size 6.3 6l 8.0 6.9 9.0 8.3 8.3 3.2 0.8 to 1.1 8 7l 8.0 9.9 9.0 8.3 8.3 3.2 0.8 to 1.1 8 10l 8.0 11.9 9.0 8.3 8.3 3.2 0.8 to 1.1 8 12l 10.0 7.9 11.0 10.3 10.3 4.6 0.8 to 1.1 10 8l 10.0 9.9 11.0 10.3 10.3 4.6 0.8 to 1.1 10 10l 10.0 12.6 11.0 10.3 10.3 4.6 0.8 to 1.1 10 12.7l (mm) code c v 16 d 20 e 25 v 35 h 50 j 63 k 80 2a 100 2b 125 voltage cx cat.8100b
conductive polymer aluminum solid electrolytic capacitors cv series standard ratings rated voltage (v)(code) surge voltage (v) esr (m?) (at 100khz 20 { c) rated ripple (marms) rated capacitance (f) case size d l (mm) tan part number leakage current (a) 1000 1300 1500 1700 2000 2000 3800 2300 3200 2400 4100 3900 2800 4400 1000 1300 1300 1400 2000 1900 3100 3700 2300 4000 2300 3800 2700 4300 1000 1300 1300 1400 1900 1800 3600 2200 3000 2300 3800 3700 2700 4200 900 1300 1200 1400 1900 1800 3600 2200 3000 2200 3800 3700 2600 4100 y50 y36 34 y27 31 21 y26 24 y26 20 21 y25 19 y55 48 y45 42 y28 33 y27 21 yy27 22 y26 20 y60 49 y50 47 y29 35 y28 26 yy28 22 23 y27 21 64 50 y55 52 y31 37 24 y29 27 yy29 23 24 y28 22 179 262 320 480 704 704 864 864 864 1056 1248 1504 1504 2176 188 224 272 400 600 600 720 880 880 1080 1080 1320 1320 1880 165 235 280 410 600 600 750 750 750 900 1100 1350 1350 1950 126 154 189 273 392 476 574 574 574 700 840 840 1050 1260 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 6.3 6 6.3 6 8 7 8 7 8 10 10 8 8 10 8 12 10 8 10 10 8 12 10 10 10 12.7 10 12.7 6.3 6 6.3 6 8 7 8 7 8 10 10 8 10 8 8 10 8 12 8 12 10 10 10 10 10 12.7 10 12.7 6.3 6 6.3 6 8 7 8 7 8 10 10 8 8 10 8 12 10 8 10 10 8 12 10 10 10 12.7 10 12.7 6.3 6 6.3 6 8 7 8 7 8 10 10 8 8 10 8 12 10 8 10 10 8 12 10 10 10 12.7 10 12.7 56 82 100 150 220 220 270 270 270 330 390 470 470 680 47 56 68 100 150 150 180 220 220 270 270 330 330 470 33 47 56 82 120 120 150 150 150 180 220 270 270 390 18 22 27 39 56 68 82 82 82 100 120 120 150 180 18.4 28.7 23.0 16 (1c) 20 (1d) 25 (1e) pcv1c560mcl1gs pcv1c820mcl2gs pcv1c101mcl1gs pcv1c151mcl2gs pcv1c221mcl6gs pcv1c221mcl1gs pcv1c271mcl7gs pcv1c271mcl1gs pcv1c271mcl2gs pcv1c331mcl1gs pcv1c391mcl2gs pcv1c471mcl2gs pcv1c471mcl1gs pcv1c681mcl2gs pcv1d470mcl1gs pcv1d560mcl2gs pcv1d680mcl1gs pcv1d101mcl2gs pcv1d151mcl6gs pcv1d151mcl1gs pcv1d181mcl2gs pcv1d221mcl7gs pcv1d221mcl1gs PCV1D271MCL2GS pcv1d271mcl1gs pcv1d331mcl2gs pcv1d331mcl1gs pcv1d471mcl2gs pcv1e330mcl1gs pcv1e470mcl2gs pcv1e560mcl1gs pcv1e820mcl2gs pcv1e121mcl6gs pcv1e121mcl1gs pcv1e151mcl7gs pcv1e151mcl1gs pcv1e151mcl2gs pcv1e181mcl1gs pcv1e221mcl2gs pcv1e271mcl2gs pcv1e271mcl1gs pcv1e391mcl2gs pcv1v180mcl1gs pcv1v220mcl2gs pcv1v270mcl1gs pcv1v390mcl2gs pcv1v560mcl1gs pcv1v680mcl1gs pcv1v820mcl7gs pcv1v820mcl1gs pcv1v820mcl2gs pcv1v101mcl1gs pcv1v121mcl7gs pcv1v121mcl2gs pcv1v151mcl1gs pcv1v181mcl2gs 40.2 35 (1v) cat.8100b
conductive polymer aluminum solid electrolytic capacitors cv series standard ratings taping specifications are given in page 23. recommended land size, soldering by reflow are given in page 18, 19. please refer to page 3 for the minimum order quantity. rated voltage (v)(code) surge voltage (v) esr (m?) (at 100khz 20 { c) rated ripple (marms) rated capacitance (f) case size d l (mm) tan part number leakage current (a) 800 1200 1100 1300 1700 1500 2000 3300 2600 2200 3400 3400 2600 3600 700 1200 1000 1100 1700 1400 3200 2000 2500 2200 3400 3300 2500 3400 1600 1800 1900 2200 1500 1700 1900 2100 1100 1300 1400 2000 yyy81 55 y63 60 y36 49 y34 29 37 yy30 28 29 y29 27 105 56 y75 70 y37 56 30 y35 38 yy31 29 30 y30 28 43 41 39 38 48 45 42 41 93 84 69 48 82 120 150 220 330 330 390 470 470 470 560 680 680 1000 71 103 126 151 277 277 340 340 340 416 491 592 592 706 160 192 240 352 136 200 240 360 170 205 300 375 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 6.3 6 6.3 6 8 7 8 7 8 10 10 8 8 12 8 10 10 8 10 10 8 12 10 10 10 12.7 10 12.7 6.3 6 6.3 6 8 7 8 7 8 10 10 8 8 10 8 12 10 8 10 10 8 12 10 10 10 12.7 10 12.7 8 10 8 12 10 10 10 12.7 8 10 8 12 10 10 10 12.7 8 10 8 12 10 10 10 12.7 8.2 12 15 22 33 33 39 47 47 47 56 68 68 100 5.6 8.2 10 12 22 22 27 27 27 33 39 47 47 56 10 12 15 22 10 12 18 12 15 57.5 72.4 92.0 50 (1h) 63 (1j) 80 (1k) 115 100 (2a) 143 125 (2b) pcv1h8r2mcl1gs pcv1h120mcl2gs pcv1h150mcl1gs pcv1h220mcl2gs pcv1h330mcl6gs pcv1h330mcl1gs pcv1h390mcl1gs pcv1h470mcl7gs pcv1h470mcl2gs pcv1h470mcl1gs pcv1h560mcl2gs pcv1h680mcl2gs pcv1h680mcl1gs pcv1h101mcl2gs pcv1j5r6mcl1gs pcv1j8r2mcl2gs pcv1j100mcl1gs pcv1j120mcl2gs pcv1j220mcl6gs pcv1j220mcl1gs pcv1j270mcl7gs pcv1j270mcl1gs pcv1j270mcl2gs pcv1j330mcl1gs pcv1j390mcl2gs pcv1j470mcl2gs pcv1j470mcl1gs pcv1j560mcl2gs pcv1k100mcl1gs pcv1k120mcl1gs pcv1k150mcl1gs pcv1k220mcl1gs pcv2a6r8mcl1gs pcv2a100mcl1gs pcv2a120mcl1gs pcv2a180mcl1gs pcv2b6r8mcl1gs pcv2b8r2mcl1gs pcv2b120mcl1gs pcv2b150mcl1gs 6.8 6.8 8.2 rated ripple current (marms) at 105 c 100khz no marked, will be put at 12th digit of type numbering system. 1 : in this case, will be put at 12th digit of type numbering system. 2 : in this case, will be put at 12th digit of type numbering system. 6 : in this case, will be put at 12th digit of type numbering system. 7 cat.8100b
|
